Workers were on scene to clean up the oil spill in Abbotsford at Trans Mountain Pipeline’s Sumas pump station in June 2020. (File photo by Shane MacKichan)

Workers were on scene to clean up the oil spill in Abbotsford at Trans Mountain Pipeline’s Sumas pump station in June 2020. (File photo by Shane MacKichan)

TSB releases final report on June 2020 oil spill in Abbotsford

Transportation Safety Board says pipeline fitting to blame for spill of up to 190K litres

A one-inch pipeline fitting has been identified as the source of a crude-oil spill last June at Trans Mountain Pipeline’s Sumas pump station in Abbotsford.

The Transportation Safety Board (TSB) of Canada on Tuesday (April 13) released the findings of its final report into the matter.

The report states that the spill – amounting to 150,000 to 190,000 litres – resulted when a one-inch compression fitting separated from tubing on a section of above-ground piping adjacent to the building that houses the “equation of state” (EOS) system.

“The failed compression fitting was used to join tubing from the discharged mainline to the EOS system,” the report states.

“From the point of release, the oil had followed a path into the pump station’s surface drainage system, through an oil-water separator, and into a culvert that discharges surface water into the south section of the property.”

As a result, 7,000 litres of the oil migrated to the agricultural field in the south section, the TSB said.

RELATED: B.C. Indigenous leaders speak out after 150,000 litres of oil spill in Abbotsford

RELATED: Inclusion of Indigenous reps after a spill part of ‘reconciliation’: Suzuki Foundation

The agency said that during the site cleanup, approximately 143,000 litres of the product was recovered, including about 6,600 litres from the south section.

The TSB said the compression fitting was installed in 2015, using the manufacturer’s instructions.

The fitting was tested in December 2015 and was found to have no leaks, the report indicates.

On the day of the spill – June 12, 2020 – alarms were triggered to indicate that a spill had occurred, and an automatic-shutdown process began, the report states.

However, the valves required to isolate the section of tubing in question were manual and were not part of this process. They remained open until Trans Mountain personnel were able to safely enter the site about five hours after the alarm sounded, the report indicates.

Meanwhile, the oil releasing from the EOS system reached the oil-water separator and continued to accumulate until it could not longer be trapped effectively, the TSB said.

The separator does not have an automated isolation system or manual valves.

“Therefore, once oil began flowing into the agricultural field, there was no means to stop it until operators could isolate the source of the release on the EOS system.”

The report states that once the source of the leak was established, Trans Mountain placed vacuum trucks at the oil-water separator and along the fence line separating the north and south sections of the property.

Site remediation started the following day, and included excavating the affected soils and recovering the free product from the groundwater, the report adds.

The TSB said a “multi-year remediation plan” was developed for contaminants that could not be removed from the site.

“The most appropriate remediation methods will be selected and implemented based on the results of continued monitoring and testing of the soil and groundwater.”

The TSB said the Canada Energy Regulator conducted emergency management of the site, did field inspections, and has monitored the progress of remediation activities.

The report says the actions taken by Trans Mountain have included developing a procedure to verify the integrity of the existing tubing systems and adding an automated isolation valve on the inlet of the EOS tubing system and a check valve on the inlet.

The company has also agreed to complete upgrades to the Sumas pump station by this summer, including containment and drainage features, a new oil-water separator, and a line containment area around the above-ground piping.

The report says Trans Mountain will also develop an internal standard for the construction and quality assurance of new tubing systems, as well as a procedure for their installation.

The Trans Mountain Pipeline transports petroleum crude oil and refined petroleum products from Edmonton to refineries and terminals in B.C. and Washington state.

Previous spills at the Abbotsford site took place in 2005, involving 210,000 litres, and in 2012, involving 90,000 litres.

RELATED: Delayed response impacted oil spill, says report



vhopes@abbynews.com

Like us on Facebook and follow us on Twitter

EnvironmentTrans Mountain pipeline

 

The Transportation Safety Board has concluded that a June 2020 oil spill at the Sumas pump station in Abbotsford was the result of a one-inch compression fitting separating from tubing on a section of above-ground piping. (Photo: Transportation Safety Board)

The Transportation Safety Board has concluded that a June 2020 oil spill at the Sumas pump station in Abbotsford was the result of a one-inch compression fitting separating from tubing on a section of above-ground piping. (Photo: Transportation Safety Board)

Just Posted

Abbotsford Christian Middle & Secondary School closed until May 25 after 10-day exposure. (File photo)
Entire population of Abbotsford Christian Middle & Secondary recommended for testing after COVID cluster

Several staff and students affected after continuous 10-day exposure; campuses closed until May 25

People take part in the Father’s Day Walk Run for Prostate Cancer Foundation BC in Chilliwack on June 21, 2015. This year’s event will still go ahead, but will not be an organized due to the COVID-19 pandemic. (Progress file)
Awareness, funds for prostate cancer still needed in pandemic, says Chilliwack man

People to walk/run their own route for Father’s Day fundraiser event for prostate cancer

Jonathan Prest had to climb way up to the top of a dead red cedar tree to rescue a terrified cat, but he made it up and down successfully. (Facebook photos)
Rosedale tree cutter rescues cat stuck 100 feet up a dead and dried-out cedar

Jonathan Prest put himself in extreme peril to get a terrified cat out of a dangerous situation

RCMP Supt. Bryon Massie, officer in charge UFVRD, and Sgt. Mike Sargent of Agassiz Community Policing holding awards from the recent ‘Recognizing Excellence’ ceremony. (RCMP)
Salute to local officers during National Police Week in the Fraser Valley

Exceptional performances and selfless acts noted during the ‘Recognizing Excellence’ awards

Screenshot from the Chilliwack Board of Education meeting held via Zoom on May 11, 2021. (Zoom)
OPINION: Enough is enough with regressive Chilliwack school trustees

No more: Heather Maahs, Darrell Furgason, Barry Neufeld need to do what they’ve been ordered to do

Prince Rupert was one of the first B.C. communities targeted for mass vaccination after a steep rise in infections. Grey area marks community-wide vaccine distribution. (B.C. Centre for Disease Control)
B.C. tracks big drop in COVID-19 infections after vaccination

Prince Rupert, Indigenous communities show improvement

A COVID-19 patient receives oxygen outside a hospital in Jammu, India, Wednesday, May 12, 2021. (AP/Channi Anand)
B.C. donates $500K to Red Cross COVID-19 relief efforts in India

The money will provide oxygen cylinders and ambulances for patients in communities grappling with the virus

Superintendent Aaron Paradis, community services officer with the Surrey RCMP, during a media availability about a recent drug bust in Port Coquitlam. (Photo: Lauren Collins)
Police seize 13 million ‘potentially fatal doses’ of pure fentanyl at B.C. drug lab

The evidence was seized at large, illicit drug manufacturing site in Port Coquitlam

Police are asking the public for help identifying a suspect who allegedly hurled anti-Asian slurs at a family in a Richmond drive-through on May 1. (Benjamin Wong/Screen grab)
Suspect at large in racist tirade at Richmond drive-thru, says RCMP

The Caucasian man was recorded May 1 yelling anti-Asian slurs at a Richmond family in the lineup

Cannabis bought in British Columbia (Ashley Wadhwani/Black Press Media)
Is it time to start thinking about greener ways to package cannabis?

Packaging suppliers are still figuring eco-friendly and affordable packaging options that fit the mandates of Cannabis Regulations

B.C. Public Safety Minister Mike Farnworth debates the province’s latest measure to control crime, March 10, 2021. The legislation allows police to impound vehicles used to transport weapons and further restricts sale of vehicle and body armour. (B.C. legislature video)
B.C. seeking ways to ‘name and shame’ gangsters, minister says

Mike Farnworth appeals to family members to talk to police

The Greater Victoria School District continues to face backlash over its wording and approach to Indigenous learners in its 2021-2022 budget talks. (Black Press Media file photo)
School district’s approach to Indigenous learners leaves Victoria teachers ‘disgusted’

Backlash grows over ‘pattern of colonial thinking permeating the leadership’

Italian-Canadian prisoners at the Kananaskis prisoner of war camp in Alberta. (University of Calgary/Contributed)
Italian moved to Okanagan with hope; he ended up being sent to a WWII internment camp

Raymond Lenzi shares his grandfather’s story ahead of Canada’s planned formal apology to Italian-Canadians

Police and fire crews were in the 18500-block of 18 Avenue around 9 p.m. Thursday (May 13, 2021). (Curtis Kreklau photo)
PHOTOS: Police investigating South Surrey vehicle fire

Unclear if blaze in the 18500-block of 18 Avenue related to Burnaby shootings: RCMP

Most Read